Water inside cabin... but where from?

Lankytim · 21-01-09, 03:50 PM

The passenger side front carpet in my Audi 100 is constantly wet, im trying to track down where the water is coming in from but does anyone know if its a commen fault with these models?

Im fed up of scraping ice from the INSIDE of the screen!

poopcoupe · 21-01-09, 04:00 PM

I had the same problem with My coupe on the passenger side. I couldnt figure it out? Then I suddenly relised that everytime I jet wash the car it got in through a dodgy door seal!!! Dont jet wash.

john johnson · 21-01-09, 04:00 PM

with a ur its generally where the bonnet pull goes through the bulkhead so may be the same avenue to persue

Tarka · 21-01-09, 04:01 PM

Could be a couple of things.

The first and simplest place to check is the plastic membrane that sits between the door metal and the interior door cards. Whip off the door card and see if the membrane is damaged or peeling away from the metal part of the door. It can even be the drain holes at the bottom of the door being blocked.

Other than that it could be a sign of a knackered heater matrix - more involving to fix to be honest.

maynd · 21-01-09, 06:34 PM

I have the exact same problem, passenger side carpet wet when it rains a lot, but when i go to jet wash no water, only in the trunk because of a rear light bad sealed.
Anyone have a clue about the passeger side water?

Puglife · 21-01-09, 07:01 PM

sunroof drains blocked or door window seals leaking allowing water inside the door.... I have soaking carpet and it originates from halfway up the Apillar (you can tell by lifting carpet and seeing where the sound deadening is wet up to).

Lankytim · 21-01-09, 07:33 PM

Thanks, lots of leads there! Its deffo not the sunroof though, as it hasnt got one.

The door seals sounds interesting. The passenger doors have had a scrape at some point and have filler at the bottom. Ill have to check to see if the drain holes have been obstructed.

qwerty2112 · 28-01-09, 09:59 PM

try sealing around windscreen rubber/ aperture, using grease in an old mastic tube. forcing nozzle under rubber and filling with grease. worked on my ur and gti. or try moving striker plate in on door so door closese tighter on door.

MikeNZ · 29-01-09, 08:57 PM

Quote:

Originally Posted by Lankytim

Thanks, lots of leads there! Its deffo not the sunroof though, as it hasnt got one.

The door seals sounds interesting. The passenger doors have had a scrape at some point and have filler at the bottom. Ill have to check to see if the drain holes have been obstructed.

Often after accident repair on the door skin the clear plastic membrane behind the door card is not replaced by the panelbeater and water comes in (it normally flows through the door when it rains and out the drain holes - the clear plastic membrane stuck to the inside of the door metal is the only thing stopping the door card and carpet getting wet). Even if still present it seems to shrink over time and split. Use new plastic sheet and gaffer tape or RTV sealant to patch or replace, and make sure that it is sealed all the way around. I have had to fix this on 3 1980s Audis I have owned.

one trick phoney · 29-01-09, 10:14 PM

Check around/in front of Battery - if ever a previous battery has been allowed to 'leak' it may have eaten through either gromits and/or body work.

21-01-09, 04:00 PM	#2
poopcoupe 21 + 19 = OLD! Classic Audi Club Member Join Date: Sep 2008 Location: Saafend! Posts: 1,738	I had the same problem with My coupe on the passenger side. I couldnt figure it out? Then I suddenly relised that everytime I jet wash the car it got in through a dodgy door seal!!! Dont jet wash. __________________ audiless...........

21-01-09, 04:00 PM	#3
john johnson Moderator of sausages Classic Audi Club Member Join Date: Sep 2008 Location: sheffield Posts: 13,331	with a ur its generally where the bonnet pull goes through the bulkhead so may be the same avenue to persue __________________ Mr OCD http://s159.photobucket.com/albums/t144/jsquatts/ Daily rs4 b7 with buckets that play havoc with my piles And if you are reading this as James may would say ' you're a cock '

21-01-09, 04:01 PM	#4
Tarka German Language Assistant Classic Audi Club Member Join Date: Jul 2007 Location: The Mild Mild West. Posts: 422	Could be a couple of things. The first and simplest place to check is the plastic membrane that sits between the door metal and the interior door cards. Whip off the door card and see if the membrane is damaged or peeling away from the metal part of the door. It can even be the drain holes at the bottom of the door being blocked. Other than that it could be a sign of a knackered heater matrix - more involving to fix to be honest. __________________ 1976 Audi 80 L - Sleeping 1977 Audi 80 GLS - W.I.P 1991 Golf Mk2 VR6 Supercharged 2003 Audi A6 Allroad - Daily

21-01-09, 07:01 PM	#6
Puglife ==>PUGSPORT!<== Classic Audi Club Member Join Date: Jan 2008 Location: Leyland Posts: 1,544	sunroof drains blocked or door window seals leaking allowing water inside the door.... I have soaking carpet and it originates from halfway up the Apillar (you can tell by lifting carpet and seeing where the sound deadening is wet up to). __________________ 1986 UR Quattro - (1982) Lombard RAC Group 4 recreation - #24 H.Demuth/J.Daniels 1981 VW mk1 golf GTi - now 5cylinder and RWD.

21-01-09, 07:33 PM	#7
Lankytim Grown up member Classic Audi Club Member Join Date: Mar 2008 Location: Stoke-on-Trent Posts: 513	Thanks, lots of leads there! Its deffo not the sunroof though, as it hasnt got one. The door seals sounds interesting. The passenger doors have had a scrape at some point and have filler at the bottom. Ill have to check to see if the drain holes have been obstructed. __________________ 1979 Allegro 1500 special (nearly back on the road after resto!) 1993 Audi Coupe 2.6 (non runner at the moment) 1996 Citroen XM 2.5 TD- Veg oil burner. 2004 Fiat Multipla 1.9 JTD ELX. "Eagles may fly high, but weasels don't get sucked into jet engines"

21-01-09, 06:34 PM	#5
maynd Grown up member Join Date: Mar 2008 Posts: 205	I have the exact same problem, passenger side carpet wet when it rains a lot, but when i go to jet wash no water, only in the trunk because of a rear light bad sealed. Anyone have a clue about the passeger side water?

28-01-09, 09:59 PM	#8
qwerty2112 Grown up member Join Date: Dec 2008 Location: wantage , oxfordshire Posts: 255	try sealing around windscreen rubber/ aperture, using grease in an old mastic tube. forcing nozzle under rubber and filling with grease. worked on my ur and gti. or try moving striker plate in on door so door closese tighter on door.

29-01-09, 10:14 PM	#10
one trick phoney Grown up member Classic Audi Club Member Join Date: Jul 2008 Location: Ilford, Essex Posts: 76	Check around/in front of Battery - if ever a previous battery has been allowed to 'leak' it may have eaten through either gromits and/or body work. __________________ Audi 200 5E Subaru Forester XT On-One Inbred 456

Thread Tools
Show Printable Version Email this Page
Display Modes
Linear Mode Switch to Hybrid Mode Switch to Threaded Mode

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
Water Mess!	ian20v	General Chat	6	19-11-09 10:49 PM
The temperature inside your car??	Coxy	General Chat	16	09-11-09 11:43 PM
Water Splash	Isimmo	General Chat	2	14-10-09 12:27 PM
water ingress	quattrokid	General Chat	28	10-05-09 09:55 PM
Water in Coupe GT	ZermattGT	Bodywork, glass & exterior fitments	16	01-05-09 09:07 PM